Handyman
Formula™
MATERIAL SAFETY DATA SHEET (MSDS)
Download this MSDS in PDF Format - requires Adobe acrobat reader
Date of Preparation: January 21, 1999. Emergency Telephone#: (561) 575-4200
Last Revision: July 21, 2006
SECTION I * PRODUCT IDENTIFICATION
|
Product Name: |
Handyman Formula™ |
|
Product Number: |
Not assigned |
|
Product Class: |
AEROSOL |
|
D.O.T. Shipping Class: |
Domestic – ORM-D Consumer Commodity |
|
|
International (I.M.O.) - Aerosol, Flammable, (each not exceeding 1 L. capacity) |
|
|
UN# 1950 |
SECTION II * HAZARDOUS INGREDIENTS
|
|
OCCUPATIONAL EXPOSURE LIMITS |
NFPA HEALTH RATING |
||
|
INGREDIENT |
PERCENT |
TLV |
PEL |
|
|
|
|
|
|
|
|
Dipropylene glycol methyl ether acetate |
60 - 70% |
N/E |
N/E |
0 |
|
Terpene Solvent |
5 - 15% |
5mg/M3 |
100PPM |
1 |
|
Terpene |
1 - 3% |
N/E |
N/E |
0 |
|
Nonionic Surfactant |
5 - 10% |
N/E |
N/E |
1 |
|
Propellant A - 70 Hydrocarbon Blend |
20 - 25 % |
1000PPM |
1000PPM |
1 |
|
45. PSIG @ 70°F |
|
|
|
|
N/E = Not Established
SECTION III * PHYSICAL DATA
|
Boiling Range: |
400° F |
|
Vapor Density: |
< 1 |
|
Percentage Volatile by Weight: |
99 |
|
1 Evaporation Rate: |
Slow |
|
Weight per gallon: |
> 1.1 lbs. |
|
Specific Gravity: |
0.786 @ 60° F |
|
Appearance: |
Clear Liquid |
|
Odor: |
Slight ether like odor, citrus |
|
Total VOC % |
9% |
SECTION IV * FIRE AND SAFETY EXPLOSION HAZARD DATA
|
Flammability Classification OSHA: |
Flammable |
|
|
Shipping Classification D.O.T.: |
ORM-D |
|
|
Flash Point: |
150°F |
|
|
Flammable Levels in Air: |
Lower: N/A |
Upper: N/A |
|
Extinguishing Media: |
Foam, Water Fog, CO2 |
|
Unusual Fire and Explosion Hazards: Do not expose to heat or flame or store above 120°F as high internal pressure may cause leaking. This material may produce a floating fire hazard.
Special Fire Fighting Procedures: Do not direct a solid stream of water or foam into hot burning spots may cause frothing and increase fire intensity.
SECTION V * HEALTH HAZARD DATA
PRIMARY ROUTE (S) OF ENTRY: Dermal, Inhalation
EMERGENCY AND FIRST AID PROCEDURE:
EYES: Flush eyes with large quantities of water to speed recovery. Face subject into wind or forced air source such as fans or air conditioning outlet.
SKIN CONTACT: Wash affected area with soap and water. Use no creams or salves.
INHALATION: No danger exists for asphyxiation. Remove persons to fresh air.
INGESTION: Severe burning heartburn sensation may cause nausea. If swallowed do not induce vomiting, call poison control, hospital emergency room or your physician immediately.
PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION
EYE EFFECTS: Tearing and redness may occur. This product has been found to have minor non persistent eye irritation and to be non toxic.
SECTION VI * REACTIVITY DATA
|
STABILITY: |
Stable |
|
HAZARDOUS POLYMERIZATION: |
Will Not Occur |
|
CONDITIONS TO AVOID: |
Heat, open flames, electrical and static discharges. |
|
INCOMPATIBILITY (Materials to Avoid): |
Strong Acids, Alkalies and Oxidizers. |
SECTION VII * SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Ventilate area. Remove all possible sources of ignition. Avoid prolonged breathing of vapors. Confine spill with inert absorbent. Wear protective equipment during cleanup.
WASTE DISPOSAL: Incinerate in an approved incinerator or dispose of in accordance with Local, State and Federal Regulations.
SECTION VIII * SAFE HANDLING AND USE INFORMATION
RESPIRATORY PROTECTION: Use NIOSH/MSHA approved Chemical/Mechanical type filter system to remove a combination or particles, gas and vapor. Use air line if necessary.
VENTILATION: Use adequate ventilation in volume and pattern to keep LEL and TLV's, in Section II, below recommended level to produce explosion or fire. General mechanical ventilation should comply with OSHA 1910.94.
PROTECTIVE GLOVES: Use rubber gloves.
EYE PROTECTION: Wear safety glasses or goggles with splash guards or side shields.
OTHER PROTECTIVE EQUIPMENT: Prevent prolonged skin contact to contaminated clothing.
SECTION IX * SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Store in a cool dry area away from sources of ignition. When storing large quantities, store in building designed and protected against fire.
DO NOT STORE IN DIRECT SUNLIGHT OR 120° F.
OTHER PRECAUTIONS: Do not take internally. If swallowed do not induce vomiting, call poison control, hospital emergency room or your physician immediately.
SECTION X * WARRANTIES AND COPYRIGHT
Disclaimer of Warranties: The supplier disclaims all expressed or implied warranties of merchantability or fitness for a specific use with respect to the product or the information provided herein, except for conformation to contracted specifications. All information appearing herein is based upon data obtained from manufacturers and/or recognized technical sources. While the information is believed to be accurate, we make no representations as to its accuracy or sufficiency. Conditions of use are beyond our control, and therefore users are responsible for verifying the data under their own operating conditions to determine whether the product is suitable for their particular purposes and they assume all risks of their use, handling, and disposal of the product. Users also assume all risks in regard to the publication or use of, or reliance upon, information contained herein. This information relates only to the product designated herein, and does not relate to its use in combination with any other material or process.